Loading...
HomeMy WebLinkAbout2021-04-05 DLI Elevator - Approved For Use Notification InnDEPARTMENT OF LABOR AND INDUSTRY 4/5/2021 APPROVED FOR USE LIFEWAY MOBILITY 563 SHOREVIEW PARK RD SHOREVIEW, MN 55126 RE: PERMIT# ELV2001-00167 Project: KAREN JACOBS Location: Oak Park Heights, MN 55082 Address: 14565 Upper 56th St N Dear Sir or Madam: Minnesota Statutes Chapter 326B provides that the Department of Labor and Industry, Construction Codes & Licensing Unit, Elevator Safety Section, inspect and approve elevators and manlifts (endless belt lifts) before they can be legally used in Minnesota. An Inspector from the Elevator Safety Section recently inspected your facility and determined it meets requirements of the Minnesota Elevator Safety Code. NOTE: Compliance with Minnesota Rules and the ANSI/ASME A17.1, Safety Code for Elevators and Escalators does not necessarily assure compliance with the Americans With Disabilities Act of 1990. Sincerely, Larry Fogleson Elevator Code Rep Construction Codes and Licensing\Elevator Inspections CC: LIFEWAY MOBILITY Julie Hultman, City of Oak Park Heights Bldg Official ElFormCE2R 443 Lafayette Road N., St. Paul, MN 55155 • (651) 284-5005 • www.dli.mn.gov An Equal Opportunity Employer InnDEPARTMENT OF LABOR AND INDUSTRY CERTIFICATE OF APPROVAL PERMIT TYPE; Elevator Permit I Installation I SITE: KAREN JACOBS Address: 14565 Upper 56th St N City: Oak Park Heights, MN This approval is for permit work performed by LIFEWAY MOBILITY under permit number ELV2001-00167. .S - ( E-3000 .Pan , a,4,4 L ) If you have questions related to the issuance of this permit call: (651) 284 5071 Department of Labor and Industry Construction Codes and Licensing I Elevator Inspections SII 443 Lafayette Road N., St. Paul, MN 55155 • (651) 284-5005 • www.dli.mn.gov An Equal Opportunity Employer SRE-3000 Elan Straight Rail Stairlift ILS-01024 B R U N O Rev. 8, 2-6-2019 for your independence Technical Specifications Page 1 of 2 SRE-3000 Elan Straight Rail Stairlift Technical Specifications MODEL NUMBER:SRE-3000 ETL-Intertek C-US Listed:Control Number:4004689 PERFORMANCE STANDARDS: PRIVATE RESIDENCE ONLY ANSI/ASME:A18.1-2005(Sec. 7)Safety Standards for Platform Lifts and Stairway Chairlifts ANSI/ASME:A18.1-2008(Sec. 7)Safety Standards for Platform Lifts and Stairway Chairlifts ANSI/ASME: A18.1-2011 (Sec. 7)Safety Standards for Platform Lifts and Stairway Chairlifts ANSI/ASME:A18.1-2014(Sec. 7)Safety Standards for Platform Lifts and Stairway Chairlifts ANSI/ASME: A18.1-2017(Sec. 7)Safety Standards for Platform Lifts and Stairway Chairlifts CSA B613 Private Residence Lifts ANSI/ASME: CSA B44.1/ASME-A17.5 Elevator and Escalator Electrical Equipment MODEL NUMBER:SRE-3000G ETL-Intertek EU Listed:Control Number:4004689 PERFORMANCE STANDARDS: EN 81-40: 2008 Safety rules for the construction and installation of lifts.Special lifts for the transport of persons and goods.Stairlifts and inclined lifting platforms intended for persons with impaired mobility RATED LOAD:300 lb (136 kg)maximum NUMBER OF PASSENGERS: 1 POWER SOURCE:24VDC comprised of 2 each 3AH 12 volt sealed maintenance-free lead acid batteries; On/Off power switch to prevent battery drain over lengthy storage periods CHARGER: 105-230VAC/1.5 A input, 24VDC/1 A output continuous monitoring,full primary cut off DRIVE: 24VDC, 16A direct drive self-locking positive geared motor, 2 pole rated 442 lb-in (50Nm)torque, 25.5 rpm output speed,with right angle worm gear box(0.18 HP max.) FINAL DRIVE: integrated 8dp gear rack on rail with a spur gear on the gearbox output shaft MOTOR CONTROLLER:custom 24VDC PWM controller with acceleration ramping BRAKING:dynamic motor braking through the motor controller,worm gear box, electro-mechanical motor brake and overspeed protection CALL/SEND CONTROL:infra-red wireless control; momentary switching requiring a user to continuously hold button to control unit ARMREST CONTROL:3-position, momentary rocker switch requiring user to continuously hold rocker switch to control unit; switch mounted under armrest SUPPORTS: clamps anchored to stair tread; normal rail position is 2"(50.8 mm)above step nose; number of clamps dependent on the length of rail; optional height-adjustable clamps available ANGLE: 22°to 45° (specials up to 52°) SPEED: maximum top speed 18 ft/min(0.09 m/s); actual speed varies depending on rider weight LENGTH OF TRACK: 15 feet 9 inches(4.9 m)and 19 feet 8 inches(6.1 m)standard;dealer to cut to fit the actual length of the stair (see application guide) Any reproduction or other use of these materials without written permission of Bruno Independent Living Aids,Inc.is expressly prohibited. Bruno Independent Living Aids,Inc.reserves the right to modify or make changes to these specifications at any time without notice. SRE-3000 Elan Straight Rail Stairlift ILS-01024 'BRUNO Rev.8,2-6-2019 for your independence Technical Specifications Page 2 of 2 TRACK CONSTRUCTION:aluminum extruded rail with covered metal gear rack; bolted joint plate at each rail joint FOOTREST:folding footrest with safety sensor panel SEAT:padded,folding and swivel with stops at 0°(forward),67°(top),and 90°(top); no swivel at lower landing; multiple-position seat height adjustments. ARMRESTS:fixed to seat frame;armrest may be individually rotated towards seat back for smaller profile when not in use and to facilitate transfers SAFETY EQUIPMENT: 1) seat swivel switch allowing operation only when chair is in center position 2) carriage safety switches 3) seat positioning belt 4) 25A manual reset breaker on motor control circuit 5) final end stop bumper at each end of rail 6) final limit switch 7) full diagnostic alarms on circuit board 8) armrest safety switches to insure barrier arms down to operate 9) Overspeed protection against free fall or run away condition 10) charging light on charger 11) 5A fuse on control circuits BATTERY CAPACITY/POWER OUTAGE: Cycles:variable depending on angle, length of run,ambient temperature,and rider weight Batteries: between 12 and 24 hours if power is disconnected WEIGHT OF UNIT: 185 lb(86 kg)without rider in a typical 15'-9"(4.9 m)installation TESTING PERFORMED: 1) Life cycle testing with full rated load at 45 degree on a 15'-9"rail 2) battery charger UL tested and listed to UL 1012 3) self-locking gear box statically tested with 2100 lb(953kg)(7 times rated load)on a 45°rail for 5 minutes with no carriage movement;test performed at manufacturer's location 4) repetitive tests performed to determine power outage cycling 5) electrical discharge to ground testing 6) Overspeed free fall testing for repeated usage OPTIONS: 1) keyed call/send controls 2) power swivel seat at top landing(up to 85°of rotation) 3) power folding footrest 4) manual folding rail 5) power folding rail Any reproduction or other use of these materials without written permission of Bruno Independent Living Aids,Inc.is expressly prohibited. Bruno Independent Living Aids,Inc.reserves the right to modify or make changes to these specifications at any time without notice. TECHNICAL DATA/SPECIFICATION r-3"TOPBACKSIDEOFRAIL MODEL:SRE-3000 ELAN STRAIGHT RAIL STAIRLIFT, PRIVATE RESIDENCE ONLY —5"RAIL POSITION FROM WALL OR RATED LOAD: 300 LBS, ONE PASSENGER OBSTRUCTION RECOMMENDED POWER SOURCE: 24 VOLT DC COMPRISED OF (2) 3 AMP/HR ,�:, r7k i � �� 12 VOLT SEALED BATTERIES 11111 ��105-230 VOLT AC 0.6 AMP, 24 VOLT DC 1 AMPCONTINUOUS MONITORING CHARGER. DRIVE: 24 VOLT DC DIRECT DRIVE SELF LOCKING POSITIVE GEARED MOTOR, � 20 BETWEEN-- 2 POLE RATED .18 HP MAX., RIGHT ANGLE WORM GEARBOX, _I ARMRESTS 50Nm (442in.lb.) TORQUE MAX., 25.5 RPM SPEED MAX., 16 AMP CURRENT MAX. 17 1/2^ SEAT SUSPENSION: RACK & PINION - INTEGRATED 8DP GEAR RACK CUSHION ON RAIL WITH SPUR GEAR ON THE OUTPUT SHAFT OF GEARBOX. TOP VIEW BRAKING: DYNAMIC MOTOR BRAKING THROUGH THE MOTOR /- CONTROLLER, WORM GEAR, ELECTRO-MECHANICAL MOTOR BRAKE AND OVERSPEED PROTECTION. 4 CONTROLS: CONTINUOUS PRESSURE ROCKER SWITCH LOCATED IP' ON THE ARMREST AND WALL MOUNTED CALL/SENDREFER TO CONTROLS LOCATED AT BOTH THE TOP AND BOTTOM 11R �\ CHART IN FOOTREST • ' MANUAL LANDINGS. WIDTH ANGLES:22 TO 45 DEGREES (SPECIALS UP TO 52 DEGREES), RIGHT OR LEFT HAND ORIENTATIONS. II TOP LOWER LANDING EXTENSION DIMENSIONS ARE LANDING FINAL LIMIT SWITCH:STANDARD BASED ON 45 DEGREE RAIL SLOPE ON AN 8" 1ST RISER HEIGHT. DIMENSIONS WILL VARY BASED ON SLOPE AND RISER HEIGHT. . 11.111 le t millii .im. i ` ru.=.........# ___� 15 3/4" 14 1/4" 0 Lr- -sEArDEPTH III/MIME 10" .. 41) ELEVATION VIEW '6 °_! ill 1. A 11 12"FOLDED 201/8" ®:\ ADJUSTABLE IFI I POSITION SEAT " ,� HEIGHT `�` 1780 Executive Drive • ris I r � LOWER Oconomowoc, WI 53066 LANDING Tel 800-882-8181 SIDE VIEWS 3" i 1 15 3/4" Fax 262-953-5501 FOOTREST RAIL DIMENSIONS SHOWN IN SIDE VIEWS HEIGHT EXTENSION WWW.bruno.com ILS-01345 ARE BASED ROM WALLOOR OBSTRUCTION POSITION 25 1/4" --TY SHEET 1 OF 3 �` CHAIR B RU N c ® EXTENSION for your independence REV. 1 (6456)(9/01/17)(BHM) ©Bruno Independent Living Aids, Inc. SRE-3000 DISTANCE FROM WALL - SEAT SWIVELED Le._,J , ,.."...........„ app rill rt, g. 27.$ 26.2 I L. 11111111.11, 1 J SEAT SWIVELED 67" SEAT SWIVELED 90° 1780 Executive Drive Oconomowoc, WI 53066 Tel 800-882-8181 Fax 262-953-5501 uu.5-01345 www.bruno.com SHEET 2 OF 3for your independence BRUNC® REV. 1 (6456)(9/O1/17)(BHM) jd"©Bruno Independent Living Aids, Inc. SRE-3000 FOLDING RAIL 4"TOP BACK SIDE OF RAIL 6"RAIL POSITION FROM WALL OR 0 A ii 5���'' R�_r' UOBSTRUCTION ,,T ,1 AUXILIARY ELEVATION VIEW loll_ RAIL FOLDED UP POSITION TOP VIEW AUXILIARY ELEVATION VIEW RAIL FOLDED DOWN POSITION z PARK IAGE hill POSITION L-I 4 rIF*47V\ - _ ...,, r 45° — �� SHOWN 48.7 MIN. PAA4RK POSITION \ �� 23.81\ 74 .1 / 7t FOLDING e . , . ., 21 SECTION 4/ OF RAIL 3 / A ADJUSTABLE JOINT SUPPORT I 1--.--15.1` *LOWER LANDING EXTENSION DIMENSIONS ARE BASED ON 45° RAIL SLOPE AND 8"RISER 1780 Executive Drive HEIGHT. DIMENSIONS WILL VARY BASED ON Oconomowoc, WI 53066 SLOPE AND RISER HEIGHT. Tel 800-882-8181 Fax 262-953-5501 ILS-01345 Folding Rail vvww.brunO.com SHEET 3 OF 3 B RU N O0 REV. 1 (6456)(9/01 /17)(BHM for your independence ©Bruno Independent Living Aids, Inc.